Recalls During August 2008
Posted on October 27, 2008
MY = Model Year
The National Highway Traffic Safety Administration (NHTSA) has issued recall notices for the following RVs. Please note that if you own an RV equipped with a Dometic or Norcold refrigerator, we recommend that you look at the brands recalled:
Motor Homes
Damon is recalling 179 MY 2008 Astoria, Tuscany, Essence, and MY 2008-2009 Astoria Pacific motor home chassis equipped with SAF-Holland ADL Series rear suspensions. In some instances the transverse beam was not properly welded which could result in a failure of the weld. If the weld fails, vehicle stability while cornering could be affected resulting in loss of vehicle control, possibly resulting in a crash. In addition, the transverse beam could drop to the ground causing sparks that could cause a fire hazard. Damon is working with Daimler Trucks/SAF-Holland to have a visual inspection of the ADL transverse beam performed. If a weld defect is identified, SAF-Holland will provide a service replacement kit that contains a new transverse beam, all necessary installation hardware, beam replacement, and instructions free of charge (please see 08E031). The recall is expected to begin during September 2008. Owners may contact Daimler Trucks at 1-800-547-0712, SAF-Holland at 1-231-773-3271 or Damon at 1-800-860-3812. 08V-391
Fleetwood is recalling 369 MY 2008 Terra and Fiesta motor homes. The battery control center (BCC) miscellaneous wire harness is routed between framing at the driver's wheel well and the front leveling jack. This routing can cause the wires to be pinched resulting in shorted or open circuits which could lead to blown fuses, house component non-operation and may result in a fire. Dealers will inspect and, if necessary, reroute the BCC miscellaneous wire harness free of charge. The recall began on August 27, 2008. Owners may contact Fleetwood at 1-800-509-3418. 08V-388
Gulf Stream is recalling MY 1999-2002 Sun Voyager, Scenic Cruise, Friendship, and Tour Master Buses and motor homes equipped with Norcold refrigerators. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. Extended operation of a leaking cooling unit could lead to a fire from gas which might escape. Gulf Stream is working with Norcold to repair these refrigerators (please see 08E030). Norcold will provide thermal switch kits to owners along with the necessary forms and instructions. The manufacturer has not yet provided an owner notification schedule for this campaign. Owners may contact Norcold at 1-800-767- 9101 or Gulf Stream at 1-574-773-7761. This recall was the subject of an Equipment Query, EQ08-009, conducted by the Office of Defects Investigation. 08V-383
Gulf Stream is recalling 5 MY 2008-2008 Tourmaster recreational vehicles equipped with Bendix SR-7 spring brake control valves. The Parker SCV brass 90 degree single check valves (SCV) which attach to the supply port of a Bendix SR-7 spring brake modulating valve can break apart. Pieces of the Parker SCV can become lodged inside the SR-7 spring brake modulating valve, potentially causing either leakage out of the SR-7 valve or preventing air from properly exhausting from the SR-7 valve. Also, due to a manufacturing defect in the internal rubber check valve inside the SR-7 spring brake modulating valves, the valves can become deformed and not seat properly. These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death. Gulf Stream is working with Daimler Trucks to have these vehicles repaired (please see 07V302). Owners can contact Daimler Trucks at 1-800-547-071 or Gulf Stream at 1-574-773-7761. 08V-416
Gulf Stream is recalling 38 MY 2005, 2008 and 2009 Friendship, Scenic Cruiser, and Tourmaster recreational vehicles equipped with ZF Model 8018 steering gears. These steering gears were manufactured in Germany. These steering gears may have been assembled with the incorrect recirculating ball spacer. This could potentially allow the recirculating balls to escape from the recirculating ball circuit resulting in a loss of steering. The operator may notice higher required steering wheel inputs, or the need for more steering wheel adjustments while driving in a straight line in combination with metallic cracking noises prior to a loss of steering. Loss of steering could result in a vehicle crash. Gulf Stream is working with Daimler Trucks to have the steering gear replaced (please see 07V343). Owners may contact Daimler Trucks at 1-800-547-0712 or Gulf Stream at 1-574-773-7761. 08V-418
Gulf Stream is recalling 50 MY 2008-2009 Crescendo, Yellowstone, and Tourmaster recreational vehicles equipped with SAF-Holland ADL Series rear suspensions. In some instances the transverse beam was not properly welded which could result in a failure of the weld. If the weld fails, vehicle stability while cornering could be affected resulting in loss of vehicle control, possibly resulting in a crash. In addition, the transverse beam could drop to the ground causing sparks that could cause a fire hazard. Gulf Stream is working with Daimler Trucks and SAF-Holland to have a visual inspection of the ADL transverse beam performed. If a weld defect is identified, SAF-Holland will provide a service replacement kit that contains a new transverse beam, all necessary installation hardware, beam replacement, and instructions free of charge (please see 08E031). Owners may contact SAF-Holland at 1-231-773-3271, Daimler Trucks at 1-800-547-0712, or Gulf Stream at 1-574-773-7761. 08V-420
Newell is recalling 80 MY 2005-2008 Model 450 motor homes equipped with ZF transmissions. These transmissions were built in Germany. There is a potential for the shift selector to malfunction as a result of a cell phone or radio being placed in close proximity to the shifter control pad. The interference from the cell phone or radio could result in an unexpected change in direction and possible crash if a specific sequence of events were to occur. Dealers will update the software to the transmission shift controller free of charge (please see 06E-100). The recall is expected to begin during September 2008. Owners may contact Newell at 1-888-963-9355. 08V-392
Newmar is recalling 1 MY 2004 Essex Diesel Pusher motor home built on a Freightliner chassis and equipped with Bendix SR-7 spring brake modulating valves. The internal rubber check valve may leak causing a delay in the application of the spring brakes to park the vehicle after the operator pulls the dash valve button. This could cause a delay or failure in applying the parking brakes which could result in a vehicle roll away, increasing the risk of a crash. Newmar is working with Daimler Trucks and Bendix to repair this vehicle (please see 07V302 and 07E037). Bendix will install a check valve repair kit for the affected SR-7 spring brake modulating valve free of charge. Owners may contact Daimler Trucks at 1-800-547-0712, Bendix at 1-440-329-9000 or Newmar at 1-574-773-7791.08V-414
Tiffin is recalling 271 MY 2007-2008 Phaeton Class A motor homes equipped with Freightliner chassis. The AAC front axle steering arm bolts with a latch lever pivot bolt assembly may have been over-tightened. Over-tightened steering arm bolts may fatigue and fracture increasing the risk of a crash. Tiffin is working with Daimler Trucks to have the steering arm tie rod fasteners inspected and replaced. The steering arm will be inspected for clearance to the king pin boss (please see 07V306). Owners may contact Daimler Trucks at 1-800-547-0712. This recall was the subject of an Equipment Query, EQ08-008, conducted by the Office of Defects Investigation. 08V-393
Winnebago is recalling 31 MY 2006-2008 Itasca Cambria, Horizon, Winnebago Access, Adventurer, Journey, Minnie Winnie, Sightseer, Tour, Vectra, and Voyage motor homes equipped with Ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 403, "Platform Lift Systems for Motor Vehicles." The anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift. A lift occupant can be injured should the lift begin to stow unintentionally. Winnebago is working with Ricon to correct the wheelchair lifts (please see 07E097). Owners may contact Ricon at 1-800-322-2884 or Winnebago at 1-641-585-3535. 08V-419
Travel Trailers and Fifth Wheels
Frontier RV Frontier RV is recalling 361 MY 2003-2006 Explorer, Ranger, and Aspen fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Frontier RV is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or Frontier RV at 1-903-247-9400. This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-377
Frontier RV of GA is recalling 66 MY 2003-2007 Explorer travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Frontier RV of GA is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or Frontier RV of GA at 1-903-247-9400. This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-378.
Gulf Stream is recalling 26,847 MY 2003-2006 Ameri-Lite, Atrium, B Touring Cruiser, Canyon Trail, Cavalier, Conquest, Crescendo, Emerald Bay, Endura, Friendship, Gulf Breeze, G-Force, Independence, Innsbruck, Kahuna Bay, Kingsport, Mako, Mini, Palm Breeze, Prairie Schooner, Scenic Cruiser, Seahawk, Sedona, Side Kick, Side Track, Stream-Lite, Sun Sport, Sun Voyager, Tourmaster, Track & Trail, Trailmaster, Ultra, Wide Open, and Yellowstone motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Gulf Stream is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or Gulf Stream at 1-574-773-7761. This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-411
Heartland RV is recalling 6,002 MY 2005-2008 Big Country, Landmark, Bighorn, Cyclone, Razor, Sundance, and Trail Runner fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Heartland RV is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or Heartland RV at 1-574-262-8030. This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-380
Jayco is recalling 222 MY 2009 Eagle SL travel trailers. The upper rear plastic cap can become detached from the rear wall due to improper cleaning of mating surface to allow proper adhesion. If this condition is not addressed, it may result in a crash, injury or death. Dealers will remove the upper rear plastic cap to install backers, new adhesive tape, add screws, and prepare the surface for proper adhesion. The recall is expected to begin during September 2008. Owners may contact Jayco at 1-800-283-8267. 08V-402
Jayco is recalling 265 MY 2007-2008 Jay Feather EXP travel trailers. A P-clamp was not installed during production that was intended to prevent the rubber liquid propane (LP) line from contacting the slide-out mechanism. If the P-clamp was not installed, the LP line could chafe, which could result in a fire, injury, or death. Dealers will inspect the P-clamp installation, add the P-clamp if it is missing, and replace any chafed rubber LP lines, rerouting them correctly, if necessary. The recall is expected to begin during September 2008. Owners may contact Jayco at 1-574-825-0608. 08V-407
Peterson Industries is recalling 5 MY 2001 Classic and MY 2001-2002 Excel Limited Edition fifth wheel travel trailers equipped with Norcold refrigerators. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. Extended operation of a leaking cooling unit could lead to a fire from gas which might escape. Peterson is working with Norcold to repair these refrigerators (please see 08E030). Norcold will provide thermal switch kits to owners along with the necessary forms and instructions. Owners may contact Norcold at 1-800-767- 9101 or Peterson at 1-785-282-6825. This recall was the subject of an Equipment Query, EQ08-009, conducted by the Office of Defects Investigation. 08V-415
Skyline is recalling 22,372 MY 2004-2007 Alliance, Aljo, Celebrity, Century, Freestyle, Layton, Rampage, Sea View, Trailrider, and Weekender fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Skyline is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or Skyline at 1-574-294-6521.This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-394
Skyline is recalling 83 MY 2007-2008 Freestyle, Rampage, and Trailrider Model 281 recreational vehicles. These vehicles may have had the axle attaching bolts, which attach the axles to the chassis, improperly installed. The clearance between the tires and these attaching bolts on this model require that the head of the attaching bolt be installed on the tire side of the axle hangers and/or shackles. Drivers may experience tire damage and can cause or contribute to premature tire failure that could result in a loss of control of the vehicle, increasing the risk of a crash. Dealers will inspect the axle attaching bolts for correct installation and the back side of the tires for damage from improperly installed axle bolts. Dealers will remove and reinstall the axle mounting bolts with the correct orientation and replace damaged tires free of charge. The recall is expected to begin during September 2008. Owners may contact Skyline at 1-800-733-4250. 08V-399
Starcraft RV is recalling certain MY 2004-2007 Antigua, Aruba, Aruba FW, Homestead, Homestead FW, Homestead Settler, Travel Star, MY 2005 Aruba Tahiti, Aruba Tahiti FW, Ambient, Homestead Rancher, Homestead Rancher FW, MY 2006 Antigua XLT, TravelStar XLT, MY 2006-2007 Starcraft, and MY 2007 Starstream and NXP motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Starcraft RV is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or Starcraft RV at 1-260-593-2550. This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-381
Sun Valley is recalling certain MY 2003-2006 Road Runner and X-treme fifth wheel and travel trailers equipped with a two-door refrigerator manufactured by the Dometic Corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. Release of coolant under certain conditions could ignite and result in a fire. Sun Valley is working with Dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained Stericycle Inc. to manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact Dometic/Stericycle at 1-888-446-5157 or
Sun Valley at 1-800-327-7684. This recall was the subject of an Equipment Query, EQ08-010, conducted by the Office of Defects Investigation. 08V-400
|
|
Please give us your comments about the
article appearing on this page. We want
to bring you the type of information that
you want and need. Thank you!
|
Independent 
